EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF …

that the compressive strength of concrete at 7 days using quarry dust and waste plastics is consistently higher than the conventional concrete using natural sand. It has been observed that the compressive strength increase upto 30% replacement of natural sand. Anithaselvasofia S. D describes the Experimental Investigation on Quarry dust ...

Effect of Granite Powder on Strength Properties of Concrete

For example, fly ash, slag and lime stone, siliceous stone powder, rock dust and quarry waste were used in concrete mixture as a partial replacement of natural sand [2]. Hence the assumption is granite powder aggregate could be an alternative to natural sand in preparation of concrete.

Partial Replacement of Sand by Quarry Dust in Construction ...

Oct 25, 2017· This Experimental study is about testing the properties of concrete before and after setting on each % replacement of sand by quarry dust in M20 and M25 grade of concrete.

CHAPTER 2 LITERATURE REVIEW - Shodhganga

CHAPTER 2 LITERATURE REVIEW ... concrete. Some of the experimental investigations on the strength and durability behaviour of concrete on the use of quarry dust in the place of natural sand are listed here. ... influence of partial replacement of sand with quarry dust in the compressive

An Experimental Investigation on Stone Dust as Partial ...

An Experimental Investigation on Stone Dust as Partial Replacement of Fine Aggregate in Concrete Sandeep Kumar Singh*, Vikas Srivastava1, V.C. Agarwal1, Rakesh Kumar2 and P.K. Mehta2 1Dept. of Civil Engineering, Sam Higginbottom Institute of Agriculture …

Experimental Study on the Effect of Cement and Sand ...

Feb 25, 2017· From the experimental studies 15% partial replacement of cement with red mud and 5% hydrated lime improved cement concrete properties. 4.Venkata Sairam Kumar NB Pandurangarao Krishna sai M L N et al: have made investigation on partial replacement of sand with quarry dust for studying mechanical properties of concrete.

The Utilization of Quarry Dust as Fine Aggregates in Concrete

During the tenure of the study, some physical and engineering properties of quarry dust and sand were determined and compared. The compressive strength of concrete was determined after replacing sand with quarry dust in various ratios. The results of the study showed encouraging results for replacement of 50% of sand with quarry dust.

Crushed rock sand – An economical and ecological ...

But, an in-depth study has not been performed to optimize the replacement level of crushed rock sand in concrete. The present study has attempted to study the effect of partial to full replacement of Natural River sand with crushed rock sand on the workability, compressive strength and flexural strength of concrete. Materials

Use of Quarry Dust to Replace Sand in Concrete – An ...

III. EXPERIMENTAL INVESTIGATION A. Mix proportioning Two grades of concrete M20 and M25 having nominal mix proportion of 1:1.5:3 and 1:1:2 respectively were used by weight and w/c ratio was fixed according to the slump requirement of 60mm. For this concrete mix, quarry dust was added for replacement of sand from 0% to in step of 10%.

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF …

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF CEMENT WITH QUARRY DUST ... with experimental investigation on strength of geo-polymer concrete and optimum percentage of replacement by replacing fine ...

addition of quarry dust in concrete - YouTube

Aug 29, 2016· EXPERIMENTAL STUDY OF THE ENHANCEMENT OF obtained, it is found that replacement of quarry dust and marble powder in concrete addition of quarry dust in concrete . addition of quarry dust in ...

Partial Replacement of Sand by Quarry Dust in Concrete

investigated the partial replacement of sand with quarry dust. Initially cement concrete cube was studied with various proportions of cement concrete + quarry dust (M 20, AND M25). The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties.

Effect on Partial Replacement of Fine Aggregate and …

Effect on Partial Replacement of Fine Aggregate and Cement by Waste Marble Powder/ Granules on Flexural and Split Tensile ... marble dust increases the strength of cement paste..This study shows the experimental investigations on the ... WMP in cement is increased by 2 % and for 10% replacement of sand the Flexure Strength in increased by 5%

Experimental investigation on partial replacement of ...

Apr 15, 2017· Experimental investigation on partial replacement of cement with silica fume and fly ash in concrete ... BEHAVIOUR OF CONCRETE BY PARTIAL REPLACEMENT OF CEMENT AND SAND WITH MARBLE POWDER AND ...

"To Study the Partial Replacement of Cement by GGBS & …

"To Study The Partial Replacement Of Cement By GGBS & RHA And Natural Sand By Quarry Sand In Concrete" 71 | Page days. Aggregates are graded not only to maintain cohesiveness of mix, but also to meet the grading requirements

Study on Compressive Strength of Quarry Dust as Fine ...

The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity. The availability of sand at low cost as a fine aggregate in concrete is not suitable and ...

Structural Behaviour of Concrete with Partial Replacement ...

In this experiment the studies, the strength characteristics of M30 grade concrete using manufactured plastic coarse aggregate as a replacement of natural coarse aggregate is conducted along with the use of quarry dust as a partial replacement of conventional natural river sand.

Experimental Investigation on Self Compacting Concrete ...

Abstract —This study presents an experimental investigation on self-compacting concrete (SCC) with fine aggregate (sand) replacement of a Quarry Dust (QD) (0%, 25%, 50%, 75%, ) and addition of mineral admixtures like Fly Ash (FA) and Silica Fume (SF) & chemical admixtures like super plasticizers (SP).

Experimental Investigation on the Effect of Replacement …

obtained with the partial replacement of river sand with 20% CGF, as against values of 35.00N/mm2 and 1.75N/mm2 obtained with the use of river sand as fine aggregate. Based Experimental Investigation on the Effect of Replacement of Sand by Quarry Dust in Hollow Concrete …

Experimental Study on Self Compacting Self Curing Concrete ...

Experimental Study on Self Compacting Self Curing Concrete by Replacing River Sand by Quarry Dust for M50 Grade Concrete. Pavan Kumar C S. 1, Reena K. 2 1. PG Student, Structural Engineering, Department of Civil Engineering, ACS College of Engineering, Bangalore, INDIA . 2

Study of Concrete Involving Use of Quarry dust as Partial ...

presented in TABLE 1. Fig.1 shows sieved quarry dust and Fig.2 shows manual mixing of quarry dust with sand. III. EXPERIMENTAL INVESTIGATION 3.1. Mix Proportion The concrete mix design was proposed by using IS 10262 [10]. The grade of concrete used was M …

(PDF) EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF …

[5]Dilip Kumar, smith singh, neetesh kumar and Shish gupth Low cost construction material for concrete as sawdust (2014). [6]H.S.suresh Chandra, G.sarangapani, and b.naresh Experimental investigation on the effect of replacement of sand by quarry dust in hallow concrete block for different mix proportion vol .no., February .

Experimental Investigations on by using Quarry Dust ...

G.Anil | A.Pavani"Experimental Investigations on by using Quarry Dust Durability Properties of Concrete" Published in International Journal of Trend in Scientific Research and Development (ijtsrd ...

Experimental Investigation on Workability of Concrete with ...

Feb 02, 2017· The percentages of quarry dust as partially replacement of cement in concrete ware 0, 10%, 15%, 20%, 25%, 30%, 35%, and 40%.From the experimental studied 25% of partial replacement of cement with quarry dust improves hardened concrete properties H. S. Sureshchandra et al. have studied on the Effect of Replacement of Sand by Quarry Dust in ...

Strength and durability properties of concrete containing ...

has also been made to durability studies on Quarry Rock Dust when compared with the Natural Sand concrete. It is found that the compressive, flexural strength and Durability Studies of concrete made of Quarry Rock Dust are nearly 10% more than the conventional concrete. Keywords: concrete, quarry rock dust, river sand, strength, properties ...

CIVIL - EXPERIMENTAL PROJECTS - Majestic Project

CIVIL - EXPERIMENTAL PROJECTS CEX001 . Experimental Investigation on Replacement of Sand by Graded Quarry Dust in Concrete CEX002. Experimental Investigation on Partial Replacement of Cement with Glass Powder CEX003. Parametric Study for Replacement of Sand by Fly Ash for Better Packing and Internal Curing ...

Effect of quarry rock dust on the flexural strength of ...

The flexural strength of concrete made with quarry dust as fine aggregate is higher (about 4.3%) than conventional river sand concrete. 2. The 10–15% rule of thumb was found to be applicable in the estimation of flexural strength of quarry-sand concrete based on its compressive strength.

Suitability of Quarry Dust as Partial Replacement Material ...

This project is an experimental investigation into the effect of using quarry dust with iron filing as a partial replacement for fine aggregates [sand] in concrete production.

Experimental Investigation on Replacement of Sand by ...

Second mixtures were prepared by replacing of sand with the Quarry dust (80%) i.e., (80% Quarry dust & 20% sand). In third mixture both Quarry dust and sand partially used i.e., 50% Quarry dust ...

EXPERIMENTAL INVESTIGATION ON PARTIAL REPLACEMENT …

EXPERIMENTAL INVESTIGATION ON PARTIAL REPLACEMENT OF CEMENT BY MARBLE POWDER AND QUARRY DUST ... the used for replacement process 25 grade concrete . The partial replacement of mix design of concrete . As percentage replacement of 20%, 25%, 30% are ... and quarry dust replacement by cement gives better compressive strength of 1.18% increased ...